[ms1991]

Hi all.

My vitara's G16B has been a little tempermental of late.

When cruising at low speeds it will sometimes just die ( 20km and lower), aswell as when im coming upto a red light and put the clutch in the revs will go straight to zero and she dies...
Other times it runs like a dream!

Is there a sensor that may be rooted and causing these problems?
lately its one thing after another and Im getting fed up!

Hope you guys can help, Thanks, Mark.

[Rossco]

Have a look at the ERG that was what was causing this in mine. I'm on my phone but ill hop on my computer and find the thread for you.

[Gwagensteve]

Rossco wrote:

Have a look at the ERG that was what was causing this in mine. I'm on my phone but ill hop on my computer and find the thread for you.

EGR?

[Rossco]

ha ya I had a dyxlesic moment

[Rossco]

here you go bud, my post is near the bottom. It fixed it for me and takes five minutes.

http://www.auszookers.com/forum/viewtop ... the+lights

[ms1991]

Cheers rossco! Will check it out and report back

[ms1991]

Hi guys.. finally had a spare bit of time after work today so i decided to check out my egr..

I found one of the two bolts missing and the only bolt that was there was loose.

I cleaned out a small film/layer of carbon buildup from the egr ports and refitted.. car seems to stay at idle a bit better, but will occasionaly drop to the little line above 0 on the tacho.. about 300rpm? then creeps back up. is this normal?

[Rhinoman]

You need to clean the passageways back to the exhaust manifold and check the throttle body too.